Tuesday, December 28, 2010

Pier & Beam versus Slab Foundation, Part 2

This is the second part in our multi-part series of posts, "Pier and Beam versus Slab Foundation." Be sure to read the first post in this series, if you haven't already.

In our last post, we discussed pier and beam foundations (sometimes called post and beam foundations), including what they were, and their pros and cons. In this post, we'll covered the basics of slab foundations.

The Basics

Slab foundations are usually the easiest (and thus the least expensive) foundations to build. The slab is a flat concrete pad poured directly on the ground. This takes minimal site preparation, very little formwork for the concrete, and less labor to build than a pier and beam foundation. Slab foundations work well on level sites in warmer climates (like what we have here in north Texas and southern Oklahama). Slab foundations can be problematic farther north because when the ground freezes during winter, this freezing may shift the slab. This may damage the structure sitting on the foundation, plumbing running through and under the foundation, and the foundation itself.

How Slab Foundations are Constructed

In most cases, the perimeter of the slab is about 2 feet deep. The interior of the slab can be as little as 4 or 6 inches thick. Below the slab sit a 4 to 6 inch layer of gravel. To keep moisture from the ground rising through the gravel to the slab, a 4-millimeter sheet of plastic is placed. Reinforcing bar (rebar) is laid out in a grid framework (supported a few inches above the plastic sheet) and the concrete is then poured over everything.

This type of foundation is commonly called a floating slab since it "floats" on the soil. What holds the foundation in place is the deeper layer of concrete around the perimeter of the foundation.

In places with common and severe winter freeze, the concrete along the perimeter extends below the frost line.

The Advantages and Disadvantages of a Slab Foundation

Slab foundations offer the following advantages:

  • Slab foundations usually take less time to construct.
  • Slab foundations require less prep work of the site.
  • Typically, slab foundations cost less, due to the two points above.
  • Since there is no crawlspace under the home, there's no risk of animals getting underneath the structure.
  • Since the slab sits on the ground, entries and exits to and from the structure are close the ground -- perhaps only a step or two. This is good news for those with disabilities or other restrictions that makes steps difficult to navigate.

On the other hand, there are a few drawbacks to slab foundations:

  • Since the plumbing and gas lines (if applicable) run directly through the concrete slab, it's more expensive to fix these problems below the home. Also, shifts in the foundation can break pipes (fresh water, sewer lines, and gas).
  • Once a foundation has failed, it can be more expensive to fix the foundation since piers have to be sunk below the home. (In contrast, a pier and beam already has piers, which may only need adjustment.)
  • Slab foundations cannot be used in homes where a basement will be built.
  • Slab foundations cannot be used in areas with significant or prolonged freezes. The seasonal upheaval and other shifts can destroy a slab foundation.
  • Concrete slabs can crack. These cracks can range from minor annoyances to major problems.

Concrete slabs can be a good choice for your home or business, but it has to be done right from the get-go, and only for the right type of conditions. If you have quesitons, feel free to contact us or shoot us a question.

21 comments:

  1. The interior of the slab can be as little as 4 or 6 inches thick. Review AC Contractors

    ReplyDelete
  2. very informative blog
    clarify each thing step by step i really like the advantages and disadvantages of slabs foundations thanks for sharing

    Pile Repairs
    Waterproofing

    ReplyDelete
  3. Gas lines (if applicable) run directly through the concrete slab, it's more expensive to fix these problems below the home.
    Heating Service Edmond

    ReplyDelete
  4. Slab foundations can be problematic farther north because when the ground freezes during winter, this freezing may shift the slab.
    regards
    Air Conditioning Repair West Memphis

    ReplyDelete
  5. Bem repairing it's really hard to repair them because of the whole eight on them.

    ReplyDelete
  6. Thanks For sharing this informative message with us...Hope This article was helpful for all.

    Sunny Isles Beach Air Conditioning

    ReplyDelete
  7. very nice. very helpful information for Concrete Repairs. thanks for the post

    ReplyDelete
  8. If you are having plumbing problems, do not hesitate to call a professional right away. Even if you do not think the problem is a big deal, it is always best to have it taken care of before it does become a really big deal.
    Houston plumbing repairs

    ReplyDelete
  9. Up here in PA, the state nazis will not let you keep your slab when replacing the home above. This cost me an additional 10 grand, yet I have had no problems in 10 years. I am a civil engineer and the ground was properly prepared with 6 inches of good gravel under the concrete. Government can tax you in so many ways.

    ReplyDelete
  10. Make a excellent exterior impression than whatever your home have good condition or bad condition on it inside, So you need to home improvement like fix the gate and necessary to add new coat of paint, Attractive door, and fence and window ledges.
    Home Repairs

    ReplyDelete
  11. This comment has been removed by the author.

    ReplyDelete
  12. Great article. How can you install an on-grade slab basement with the house in place? I would want to raise the house to approx. 10ft. and eventually make that basement 7ft - 8ft. Thanks.

    ReplyDelete
  13. This comment has been removed by the author.

    ReplyDelete
  14. يمكنك ترك مهمة تنظيف خزانات بمكة على شركة العنود وكذلك عزل خزانات بمكة وسيقوم بهما فريق متخصص بهذا العمل.

    ReplyDelete
  15. I am very grateful to report that going into my 5th year as the Mine Inspector there have been no reported mine injuries. I will continue to be diligent in my duties. Thank you for your support.
    Buy Fencing

    ReplyDelete
  16. شركة نقل عفش بالطائف
    أصبحت شركات نقل عفش بالطائف من أهم الشركات التي تعمل في مجال النقل منذ أكثر من 10سنوات وحصلت على ثقة العديد من عملاء الطائف الكرام، فهي الشركات التي تحرص على أن تقدم خدمات متميزة ولها أهمية كبيرة في العمل ومنها:
    ● خدمة فك وتركيب الأثاث.
    ● استخدام أجود مواد التغليف والتعبئة.
    ● الاعتماد على عمال ذو خبرة طويلة
    ● توفير أسطول من السيارات لنقل الاثاث والعفش.
    ● خدمة تنظيف بالطائف.
    ● خدمة مكافحة حشرات بالطائف.
    حيث لا يقتصر عمل الشركة وخدماتها إلى هنا فقط بل أن الشركة تعمل جاهدة لتقديم أفضل ما لديها في نقل عفش بالطائف.

    ReplyDelete
  17. all-about-foundation-repair.blogspot.com/2010/08/pier-beam-versus-slab-foundation-part-2.html

    ReplyDelete
  18. Shadow Creation is the process to change the color of an image or video..Shadow Creation It means correcting the lighting, white color balance, red or blue color balance, so that the image looks more clear or natural

    ReplyDelete